T HE year-long 2010-2011 UK trial of the electric MINI E was a huge success with almost all the participants saying afterwards that they would consider buying an electric car. BMW has just published its findings from the trial following a thorough de-briefing of the drivers and analysis of the miles they drove.
Some key findings:
• Over 250,000 miles driven on UK roads
• Average cost to charge less than 2p per mile
• Average daily distance driven 29.7 miles
• Virtually all recharging carried out at home
• Almost all participants said they’d consider buying an electric car.
Understanding how electric cars are driven in the real world has taken an important step forward with the release of data from the MINI E field trial in the UK. 62 members of the public and 776 pool users ran the battery powered hatchbacks over two six-month periods.
The early findings have already informed the development of t he 2011 BBMW Active E car, a four-seat car based on the BMW 1 Series Coupe, but the biggest beneficiary will be the BBMW i3, the first purpose-built EV from the BMW Group, set for launch in 2013.
The UK trial discovered that everyday use of the electric MINIs didn’t radically differ from the typical driving patterns of a control group of drivers of conventionally powered cars in the same segment. In fact, the daily journey distance of 29.7 miles was slightly more than the 26.5 miles recorded by the control cars, a mix of MINI Coopers and BMW 116i models.
The MINI E, road tested by the public for a year.
DAILY DRIVES
Interestingly, the UK average daily distance driven for private cars overall is less than 25 miles. With information gathered by on-board data-loggers, the average single trip distance was recorded as 9.5 miles compared to the UK average of seven miles.
Four out of five people reported that 80 percent of their trips could be done exclusively in the MINI E, and this increased to 90 per cent of users saying that with the addition of rear seats and a bigger boot, all their trips could have been done in the MINI E.
84 percent said that severe the severe low temperatures during both phases of the field trial affected the distance that could be driven between charges, but despite that, four out of five participants told the researchers they thought the MINI E was suitable for winter use, with one user, Janet Borgers, saying she “regularly did 88 miles in a single journey in the cold weather”. Another female commuter clocked up almost 8,000 miles over a September to March period.
Given the daily driven distance of just under 30 miles, the drivers felt confident enough not to have to charge their MINI E every night. In fact, the average was 2.9 times a week according to information fed back via electricity smart meters, with special night-time tariffs successfully encouraging individual drivers to charge when it was cheapest.
Nine out of ten drivers told researchers charging actually suited their daily routine, with 81 percent agreeing with the statement, “I prefer to plug in the car than go to a fuel station”. The running cost-savings were appreciated by users, with one participant telling researchers the thing she’d miss most was: “the money I will have to start paying for fuel again!”
Most charged at home, with 82 percent using their wall-mounted charging box 90 percent of the time. The lack of a comprehensive public charging infrastructure in the UK was noted, with four out of five participants (82 percent) saying they thought that it was “essential” that a network of charging points was established. However, almost three-quarters (72 percent) said they were able to use their car perfectly adequately right now as they had access to private charging.
The MINI E pioneers who paid to be part of the road trials.
SILENCE IS GOLDEN
Asked about their driving experience, the trial participants were full of praise. Every single one enjoyed the quietness, with one user quoted as saying: “I like the silence – it’s very futuristic and it causes a reaction when people notice you pull away without making a sound.”
And they all agreed with the statement: “electric vehicles are fun to drive.” The reason was partly down to the “fast pick-up and quick acceleration” of the 204hp MINI, again a statement that 100 percent agreed with. One even went so far to say it was “absolutely the best car I have ever driven”.
Driving efficiently to extend the range was seen as part of the enjoyment rather than a chore. Understanding that use of the regenerative braking could increase the range by approximately 15 percent, three quarters of the users (74 percent) agreed with the statement that it was “a game for me to use the regenerative braking in a way that enables me to reach my destination without draining the battery.”
Asked by the Oxford Brookes University researchers for suggestions to deal with the potential danger from the low noise at low speeds, over half (56 percent) said that instead of an artificial noise, the driver should pay more attention. However just over a quarter (28 per cent) said they’d like to have a warning noise below 12.5mph.
Almost all participants (96 per cent) said they’d consider buying an electric car as a result of taking part, and half (51 per cent) revealed they would pay a third more for an EV. A third (30 per cent) said they’d consider taking the plunge within a year, while 55 per cent said they’d hold fire for two or more years.
The trial found that one week was all that was needed for customers to adapt to the characteristics and peculiarities of driving an EV, such as charging, range, regenerative braking and low noise. However those company car drivers invited to use the MINI E as a pool car on a less frequent basis needed increased training and support during the initial period of vehicle use in order to consolidate their learning.
COMPANY FLEET USE
Fleet use was a big part of the trial with organisations in the UK and in Europe reporting positive feedback from both individual drivers and also fleet managers monitoring the MINI E’s use as a pool car. Those users who swapped out of their regular car reported that the MINI E was fine for 70 percent of journeys made during the working day, while the pool car success rate was even better with between 80-90 per cent of regular trips achievable.
The speed of charging was an important consideration for fleet users, while managers also flagged up the need for a clear procedure for the efficient charging of pool vehicles. Companies that participated included Scottish and Southern Energy, Oxfordshire County Council, and Oxford City Council.
The MINI E trial was one of eight UK projects supported by the £25m Ultra Low Carbon Vehicle Demonstrator Programme, funded by the Technology Strategy Board and Department for Transport. These are aimed at bringing forward the introduction of viable electric passenger vehicles to the UK.
Suzanne Gray, General Manager of BMW i said: “The feedback from the trial has been invaluable in helping our understanding of how people really respond to electric cars and other factors necessary to support electric car drivers. With this information we will be in a strong position to provide a well-rounded product and service proposition to customers of the BMW i3 and to work with other players in the electric vehicle market to make it a successful experience for a new generation of users.”
The MINI E Trial in numbers:
• 40 MINI Es
• 12 months
• 138 drivers (32 women 106 men)
• 258,105 miles
• 33,345 journeys
• 80,282 kWh Electricity
• Highest mileage by an individual driver over six months: 7954 miles
• Average mileage per vehicle over six months, including fleet pool cars: 3226
• Average cost to charge over six months: £60, less than 2p per mile
ABOUT THE MINI E
The MINI E is a two-seat development of the familiar MINI Hatch. It is powered by a 204hp electric motor that also generates 220 Nm of torque. It is driven by battery power in the form of a sophisticated 35 kWh Lithium-Ion battery containing 5,088 cells. The battery was charged by a special home charger supplied by consortium partner Scottish and Southern Energy. This enables a charge time of 3.5 hours at 32 amps. The MINI E has a top speed of 95mph and an official range of 149 miles (according to FTP72 standards), although a realistic range is 112 miles.
LINK
MINI